Hi im looking for 2002 Chevrolet Express Van L31 5.7 Litre 4L60 4x4 (12212156).bin . or will the 2wd bin
Hi im looking for 2002 Chevrolet Express Van L31 5.7 Litre 4L60 4x4 (12212156).bin . or will the 2wd bin
Hello,
The 4X4 vans were built from a 2wd van by an outside contractor. You should start with a 2wd .bin file.
Hello! so, what did you come up with? I see the 2wd version on here. That's also what I am operating with, however I am converting it to manual. Did you figure out a 4wd, for that is part of what I got going on!
I have a 411 PCM and I used PCM Hammer to update it to the 2156 OS. I am swapping a Gen 3 5.3 V8 with 4L80 into a Dodge. I would like to segment swap the 4L80 portion since that combo was never sold by GM. I see the only 2156 file with a 4L80 here is for a pre-LS (L31) Express van. Can I use that file for the segment swap?
Thanks.
UPDATE
I used LS Droid to segment swap the Van 4L80 file (see below), and PCM Hammer to write it to my 411 PCM- no errors. I did the transmission and transmission diagnostics. The base file was the 2002 Silverado 5.3 DBC no EGR from post #8, I modified it by changing the tach output from 6/6 to 3/3 and disabled some MIL codes for the rear O2 sensors. I'll update here if it works, I'm still a ways from starting my swapped engine. I'm attaching the new bin file.
UPDATE #2
When I checked the segment swapped file with HP Tuners, it showed as backwards- the engine was a 5.7 not 5.3, and the trans was a 4L60, not 4L80. As such, I don't think this file is usable as-is.
UPDATE #3
I found my error was in LS Droid. I presumed the green button meant you were swapping that function, and the red one meant you were not. That's backwards. I deleted the file until I can fix it.
UPDATE #4 11/7/20
Updated file attached. My truck developed a mechanical problem (oil leak), but the tune allowed it to run OK. As I recall, it has a number of MIL codes disabled such as EGR and secondary O2 sensors, AC and VATS are disabled, and the tach hi/low resolutions were modified. I was not able to drive the truck to verify the trans shifted properly, so use at your own risk. It did show up as a 5.3/4L80 in HP Tuners though.![]()
Last edited by 95_C4; 11-08-2020 at 01:41 AM. Reason: Attached corrected file
Any luck on swapping the 5.3/4l80 combo yet? I could use it if it's done
Just updated the prior post with the revised file. Give it a try and let me know how it goes, I'm down for at least a couple of weeks.
Possibly someone will share a stock 2002 Camaro LS1 with Manual .bin
Thanks in advance,
dave w
A little off reach of the thread but hth's
-Carl
My hero. This is the exact file I was looking for.
Hi Guys, im very new here, these are what i can contribute for now all stock
Live like you're on vacation
Bookmarks